Failed HC emissions!

[Michael Jez]

HCs are closely related to the cat. Eighter your engine is dumping too much
fuel or the cat is just bad. Do they give ya a print out of what the HCs and
others look like ? Looking at CO readings U can determine if the feedback
system- O2, is working fine. If it stays somewhat close to linear sweep
accross the line- but has small bumps up and down down that CO test... then
the O2 is working, if U see large spikes and it goes off the scale then the
O2 is failing and is not recovering in time which would cause the car to run
rich, and the HCs will be too high. Another thing I see alot is people go in
for a test with the car not fully warmed up. I like to go out drive it for
30 min HARD, and when waiting for my test I sit there holding the gas at
2500RPM and reving it up sometimes to keep the cat lit off and super hot to
make sure its operating at its full efficiency. If U can list some things
you have done to the car if anything ? like mods or tune up things ? If U
don't have a PAIR valve on the front of the engine- all 91-93s have it then
it will cause the HCs to go up and might not pass the test. I would start
off with a cap/rotor/wires/plugs. Make sure the timing is at 13deg when
going in for emissions ( put it back at 17 or 19 after the test )- it will
feel slow as hell but trust me I passed with flying colors with retarded
timing- it helps the NOx. Also run some injector cleaner through it- but
make sure when U do go in for a re-test that U have ran all the injector
cleaner out- fill the tank up dump the cleaner in the tank, drive it till
empty and run the 2nd tank to empty also. The injector cleaner will make the
car fail also if U drive in on that stuff. But the NOS injector cleaner
works really good- I swear by it. Then after that install a new fuel filter,
clean out the K&N or repleaced any dirty filters, do a oil change, get some
Redline MTL tranny fluid in the trans :) Reground the MAF, and give it a
shot at the emissions place. Make sure the engine is fully warmed up and U
go around beatting on the car to warm the cat up. Even brand new cars will
fail the test if the cat is not warmed up.
Mike Jez
93 SE-R GTi-R, fully built monster- emissions exempt :P
01 Max no cats - no emission tests :P